Open Cell Spray Foam Cathedral Ceiling

We are in climate zone 4a and we used zip roof.

Open cell spray foam cathedral ceiling.

This is more common with closed cell foam but it happens with open cell foam too. This makes the foam a softer more flexable material. In general closed cell foam is the best choice for unvented cathedral ceilings. Spray foam installers didn t understand the building envelope and sprayed either too little or too much.

The extra depth of traditional 2 x 12 rafters is not needed. First closed cell foam has a 60 percent higher r value per inch than open cell 6 3 vs. It is also one of the most expensive and most building inspectors will not allow it to be left uncovered for fire code reasons. Insulating a cathedral ceiling with foam it green.

The higher r value reduces condensation when moist interior air hits the now less cold ceiling vice versa in summer with humid outside air. Open cell foam is full of cells that aren t completely encapsulated. Cathedral ceilings spray foam insulation. These should have straightforward framing with no skylights and with direct access to soffit and ridge vents.

In other words the cells are deliberatly left open. Closed cell foam ceiling insulation in a vaulted ceiling offers substantial advantages over open cell. Spray foam contracts and pulls away from framing. A less expensive alternative is the more traditional vented cathedral ceiling insulated with fiberglass cellulose or open cell foam.

Spray foam installers missed some of the air leakage sites. Assuming you have full access to the joist spaces from below you could certainly spray foam up against the roof sheathing. This is best for simple cathedral ceilings that are easy to ventilate. Treat your cathedral ceiling just like a wall with a different angle.

Using foam it green spray foam insulation in your cathedral ceiling can give you much. If you re concerned about how you should be insulating cathedral ceilings icynene spray foam insulation is the ideal choice since it can aid in early detection of situations such as roof leaks and wind driven moisture intrusion icynene spray foam ca be applied to insulate any space or unique angle. When framing the roof of a cathedral ceiling use 2 x 10 lumber for the roof rafters. Hi we are building a new home where the great room section has a cathedral ceiling with dormers on each side.

Spray foam isn t thick enough. Here s how you do it. A spray insulation is referred to open cell or closed cell because of the difference between the small bubbles cells that make up the foam. Most experts agree that closed cell foam is best for unvented cathedral ceilings while vented cathedral ceilings can be insulated with less expensive open cell foam.